牛粪压榨机

2019-12-19  来自: 新乡市圣达轻工机械有限公司 浏览次数:2465

牛粪压榨

牛粪浆状的生牛粪是奶牛场的一个主要问题来源,由于臭味和严格的环境法规,Gaushaala在世界各地都有同样的处理方法。

这种情况发生在牛粪和冲洗水一起被收集的农场中,冲洗水通过农场的加压水嘴被应用。泥浆通过专门为泥浆输送至泥浆池而创建的小型水路收集在泥浆池中。

根据机器的容量,物料通过简单有效的泥浆泵从这些坑进入脱水螺旋压力机。

与生牛粪相比,牛粪浆的液体含量要高得多,其游离水含量在80-90%左右,固体含量在10%左右,还含有一定量的吸收水分。

在同样的脱水过程中,脱水螺旋压力机应除去所有80-90%以上的游离多余水分,同时还应除去材料一定量的吸收水分。

这里的脱水螺旋压力机必须更多地关注自由多余水的排水,而不是材料的脱水,因为自由多余水的量明显较高。

牛粪压榨后含水率为50-55%

COW DUNG SLURRY

Cow Dung Slurry like Raw Cow Dung is a major source of problem for the Dairy Farms, Gaushaala's across the world due to the foul smell and the strict enviornmental laws for the disposal for the same.

This happens in farms where the cow dung is collected along with wash water applied through pressurized water nozzles along the farm. The slurry is collected in slurry pits through small water ways created specially for the transport of the slurry to the pit.

The material is fed from these pits into the dewatering screw press through simple and effective slurry pumps as per the capacity of the machine.

Cow Dung Slurry has a much higher content of liquid as compared to the Raw Cow Dung , it has around more than 80-90% of free water and around 10% of solid content which also contains a certain amount of absorbed moisture.

In the dewatering process for the same , the dewatering screw press shall remove all the free excess water which more than 80-90% and also remove a certain amount of absored moisture of the material.

The dewatering screw press here has to focus more on the drainage of the free excess water than the dewatering of the material as the amount of free excess water is substaincially higher.

关键词: 压榨机           

产品展示

相关资讯 更多>>